›› 2018, Vol. 39 ›› Issue (8): 2941-2950.doi: 10.16285/j.rsm.2018.0588

• 岩土工程研究 • 上一篇    下一篇

基于黏度时变性的桩端压力浆液上返高度模型及工程应用

戴国亮1, 2,万志辉1, 2,竺明星3,龚维明1, 2   

  1. 1. 东南大学 混凝土及预应力混凝土结构教育部重点实验室,江苏 南京 210096;2. 东南大学 土木工程学院,江苏 南京 210096; 3. 中国能源建设集团江苏省电力设计院有限公司,江苏 南京 211102
  • 收稿日期:2018-04-10 出版日期:2018-08-11 发布日期:2018-09-02
  • 通讯作者: 万志辉,男,1990年生,博士研究生,主要从事桩基础与深基础工程方面的研究工作。E-mail:seuwanzhihui@163.com E-mail:daigl@seu.edu.cn
  • 作者简介:戴国亮,男,1975年生,博士,教授,博士生导师,主要从事岩土工程教学和科研工作
  • 基金资助:

    国家重点研发计划专项项目(No. 2017YFC0703408);国家自然科学基金资助项目(No. 51478109,No. 51678145);中国博士后科学基金面上项目(No. 2017M611955);江苏省博士后科研资助计划(No. 1701028B)。

The model of grout migration height for pressured grouting at pile tip based on time-dependent behavior of viscosity and its engineering application

DAI Guo-liang1, 2, WAN Zhi-hui1, 2, ZHU Ming-xing3, GONG Wei-ming1, 2   

  1. 1. Key Laboratory of Concrete and Prestressed Concrete Structures of Ministry of Education, Southeast University, Nanjing, Jiangsu 210096, China; 2. School of Civil Engineering, Southeast University, Nanjing, Jiangsu 210096, China; 3. China Energy Engineering Group Jiangsu Power Design Institute Co., Ltd., Nanjing, Jiangsu 211102, China
  • Received:2018-04-10 Online:2018-08-11 Published:2018-09-02
  • Supported by:

    This work was supported by the National Key Research and Development Program of China (2017YFC0703408), the National Natural Science Foundation of China (51478109, 51678145), the China Postdoctoral Science Foundation Funded Project (2017M611955) and the Jiangsu Planned Projects for Postdoctoral Research Funds (1701028B).

摘要: 桩端后压浆浆液上返高度对后压浆桩承载力的计算影响较大。基于幂律型流体的黏度时变性特征,推导了考虑黏度时变性的桩端压力浆液上返的理论计算公式,并给出了参数的确定方法及成层土中浆液上返高度的迭代算法;结合台州湾大桥的接线工程,利用电磁波CT对桩基后压浆的加固效果进行了探测分析。结果表明,采用浆液沿压浆管道阻力损失的拟合值并考虑黏度时变性得到的浆液上返高度的计算结果与实测结果基本吻合且偏于安全,而忽略黏度时变性得到的计算结果偏大,会对后压浆桩的承载力设计造成不利影响。此外,电磁波CT能观测到桩体、水泥浆加固体及土体的分布情况,且能推测出水泥浆液在桩端的扩散范围和沿桩身的上返高度,可用于评价后压浆桩的压浆效果。研究成果可为后压浆桩的设计和效果检测提供参考和指导。

关键词: 幂律型流体, 黏度时变性, 桩端后压浆, 上返高度, 电磁波CT

Abstract: The grout migration height has a remarkable influence on the calculation of bearing capacity for post-grouting pile. Based on the time-dependent behaviors of power-law cement grout, a theoretical expression to calculate upward grout migration along the pile side was proposed with consideration of time-dependent behavior of viscosity. The methods to determine the parameters and to iteratively determine the grout migration height in the layered soils were presented, respectively. Moreover, based on post-grouting project of the connecting engineering of Taizhou Bay Bridge in Zhejiang Province, the reinforcement effect of post-grouting piles was analyzed by means of electromagnetic wave CT. The results show that the predicted results of grout migration height on the basis of fitting value of pressure loss along the grouting pipeline and time-dependent behaviors of viscosity are consistent with measured results, which verifies the rationality of proposed expression for grout migration height. However, an overestimated bearing capacity of post-grouting piles may be obtained when ignoring the influence of time-dependent behaviors of viscosity, which has an unfavorable influence on pile design. Additionally, the electromagnetic wave CT can detect the distribution pattern of the pile, injected grout and soil, and can also deduce the diffusion range of cement grout at pile tip, as well as the grout migration height along the pile shaft, which can be applied to assess the grouting effect of grouted pile. The research results can provide reference and guidance for design and effect detection of post-grouting piles.

Key words: power-law fluid, time-dependent behavior of viscosity, post-grouting at pile tip, grout migration height, electromagnetic wave computerized tomography

中图分类号: 

  • TU 473

[1] 荣驰, 陈卫忠, 袁敬强, 张铮, 张毅, 张庆艳, 刘奇, . 新型水玻璃−酯类注浆材料及其固沙体特性研究[J]. 岩土力学, 2020, 41(6): 2034-2042.
[2] 黄生根,刘东军,胡永健,. 电磁波CT技术探测溶洞的模拟分析与应用研究[J]. , 2018, 39(S1): 544-550.
[3] 万志辉,戴国亮,龚维明, . 珊瑚礁灰岩层后压浆桩增强效应作用机制[J]. , 2018, 39(2): 467-473.
[4] 张连震,张庆松,刘人太,李术才,王洪波,李 卫,张世杰,朱光轩. 考虑浆液黏度时空变化的速凝浆液渗透注浆扩散机制研究[J]. , 2017, 38(2): 443-452.
[5] 杜 野,裴向军,黄润秋,何智浩,张佳兴. 黏度时变性注浆材料流动特性与应用研究[J]. , 2017, 38(12): 3498-3504.
[6] 杨志全 ,侯克鹏 ,郭婷婷 ,马 秋. 黏度时变性宾汉体浆液的柱-半球形渗透注浆机制研究[J]. , 2011, 32(9): 2697-2703.
[7] 张忠苗,邹 健,刘俊伟,贺静漪. 桩端后注浆浆液上返高度的理论研究[J]. , 2010, 31(8): 2535-2540.
[8] 马天抒,龚维明,戴国亮. 黄土地区后压浆钻孔灌注桩承载力特性试验研究[J]. , 2009, 30(S2): 362-366.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
No Suggested Reading articles found!