上横山多层页岩矿床低强度相似材料试验模型研究

›› 2014, Vol. 35 ›› Issue (S2): 114-120.

上横山多层页岩矿床低强度相似材料试验模型研究

叶义成^{1, 2}，施耀斌^{1, 2}，王其虎^{1, 2}，姚囝^{1, 2}，鲁方^{1, 2}，岳哲²

1. 湖北省页岩钒资源高效清洁利用工程技术研究中心，武汉 430081；2. 武汉科技大学资源与环境工程学院，武汉 430081

收稿日期:2014-05-02 出版日期:2014-10-31 发布日期:2014-11-12
通讯作者: 王其虎，男，1987年生，博士研究生，主要从事采矿工程研究。E-mail: wang4058113@163.com E-mail:yyc60@126.com
作者简介:叶义成，男，1960年生，硕士，教授，博士生导师，主要从事采矿工程和安全工程研究。

Test model research on low strength similar material of Shanghengshan multilayer shale deposit

YE Yi-cheng^{1, 2}, SHI Yao-bin^{1, 2}, WANG Qi-hu^{1, 2}, YAO Nan^{1, 2}, LU Fang^{1, 2}, YUE Ze²

1. Hubei Provincial Engineering Technology Research Center of High efficient Clean Utilization Shale Vanadium Resource, Wuhan 430081, China; 2. School of Resources and Environmental Engineering, Wuhan University of Science and Technology, Wuhan 430081, China

Received:2014-05-02 Online:2014-10-31 Published:2014-11-12

摘要/Abstract

摘要： 通过相似配比试验，研制不同砂胶比的低强度相似材料，分析了砂胶比和胶结材料中水泥含量对其物理和力学性质的影响及其变化规律。根据上横山多层页岩矿床赋存条件和相似模拟试验要求，确定了3个可行的、有效的相似材料配比，结合相似模拟条件构筑了多层页岩矿床相似材料模型。试验结果表明，相同砂胶比的低强度相似材料的密度、抗压强度、弹性模量和泊松比均随胶结材料中水泥含量的增加而增大；密度、孔隙率、弹性模量和泊松比在低砂胶比条件下具有更小的波动性。进一步研究发现，选择的低强度页岩相似材料实际相似常数与设计相似常数误差≤1.77%；利用数值模拟回采矿床矿柱的变形特征与相似模拟试验基本相似，应变变化幅度≤8.76%，试验模型在多层页岩矿床模型试验研究上具有一定的合理性。研究结果为有效的进行多层页岩矿床地下开采研究提供科学依据和试验基础。

关键词: 相似模拟模型, 低强度相似材料, 配比试验, 页岩, 多层矿床, 上横山

Abstract: Different proportions of aggregate and adhesive materials of low strength similar material were developed by similar proportioning test, and the influences of sand-binder ratio and cement content of cemented material on similar material properties were analyzed. Then three feasible and effective proportions of similar materials were determined and a multilayer shale deposits model was established based on condition of deposit and experimental. The results show that the density, uniaxial compressive strength (UCS), elastic modulus, and Poisson's ratio increase with the cement content of cemented material increasing. And the density, porosity, elastic modulus, and Poisson's ratio are less volatility in low sand-binder ratio. Further studies prove that the error between actual similar constant and design similar constant of low strength similar material is less than 1.77%. Meanwhile, combining with the results of numerical simulation, the pillar strain variation between numerical simulation and similar simulation test is less than 8.76%, and the deformation characteristics agree well with each other. It indicats that test model is reasonable and effective in studying multilayer shale deposits model experiment. The study results provide an effective scientific basis and experimental basis of multilayer shale deposit underground mining research.

Key words: simulation model, low strength similar material, proportioning test, shale, multilayer deposit, Shanghengshan

中图分类号:

TU 452

叶义成，施耀斌，王其虎，姚囝，鲁方，岳哲,. 上横山多层页岩矿床低强度相似材料试验模型研究[J]. , 2014, 35(S2): 114-120.

YE Yi-cheng , SHI Yao-bin , WANG Qi-hu , YAO Nan , LU Fang , YUE Ze,. Test model research on low strength similar material of Shanghengshan multilayer shale deposit[J]. , 2014, 35(S2): 114-120.

参考文献

相关文章 15

[1]	修乃岭, 严玉忠, 胥云, 王欣, 管保山, 王臻, 梁天成, 付海峰, 田国荣, 蒙传幼, . 基于非达西流动的自支撑剪切裂缝导流能力实验研究[J]. 岩土力学, 2019, 40(S1): 135-142.
[2]	张钰彬, 黄丹. 页岩水力压裂过程的态型近场动力学模拟研究[J]. 岩土力学, 2019, 40(7): 2873-2881.
[3]	纪国法, 李奎东, 张公社, 李少明, 张蕾, 刘炜, . 页岩I型断裂韧性的分形计算方法与应用[J]. 岩土力学, 2019, 40(5): 1925-1931.
[4]	朱赛楠, 殷跃平, 李滨, . 二叠系炭质页岩软弱夹层剪切蠕变特性研究[J]. 岩土力学, 2019, 40(4): 1377-1386.
[5]	申海萌, 李琦, 李霞颖, 马建力, . 川南龙马溪组页岩不同应力条件下脆性破坏特征室内实验与数值模拟研究[J]. 岩土力学, 2018, 39(S2): 254-262.
[6]	唐建新，腾俊洋，张闯，刘姝, . 层状含水页岩蠕变特性试验研究[J]. , 2018, 39(S1): 33-41.
[7]	李玉丹，董平川，周大伟，吴子森，汪洋，曹耐. 页岩气藏微裂缝表观渗透率动态模型研究[J]. , 2018, 39(S1): 42-50.
[8]	侯公羽，李小瑞，梁洪垚，梁金平，周蒙辉，崔永科，. 高强石膏材料配比研究及其在围岩试件(厚壁圆筒) 开挖卸荷试验中的应用[J]. , 2018, 39(S1): 159-166.
[9]	赵子江，刘大安，崔振东，唐铁吾，韩伟歌,. 半圆盘三点弯曲法测定页岩断裂韧度(KIC) 的实验研究[J]. , 2018, 39(S1): 258-266.
[10]	左宇军，孙文吉斌，邬忠虎，许云飞,. 渗透压–应力耦合作用下页岩渗透性试验[J]. , 2018, 39(9): 3253-3260.
[11]	张萍，杨春和，汪虎，郭印同，徐峰，侯振坤，. 页岩单轴压缩应力-应变特征及能量各向异性[J]. , 2018, 39(6): 2106-2114.
[12]	腾俊洋，唐建新，张闯, . 层状含水页岩的抗拉强度特性试验研究[J]. , 2018, 39(4): 1317-1326.
[13]	汤积仁，卢义玉，陈钰婷，张欣玮，敖翔，贾云中，李倩,. 超临界CO2作用下页岩力学特性损伤的试验研究[J]. , 2018, 39(3): 797-802.
[14]	索彧，葛洪魁，王小琼，孟范宝，刘峻嵘. 页岩岩屑高精度波速测量的仪器与方法[J]. , 2018, 39(1): 385-392.
[15]	刘俊新，张可，刘伟，施锡林,. 不同围压及应变速率下页岩变形及破损特性试验研究[J]. , 2017, 38(S1): 43-52.

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed