›› 2015, Vol. 36 ›› Issue (2): 361-368.doi: 10.16285/j.rsm.2015.02.009

• 基础理论与实验研究 • 上一篇    下一篇

考虑黏度时变性的水泥浆液盾构壁后注浆扩散规律及管片压力模型的试验研究

刘 健,张载松,韩 烨,吴 星   

  1. 山东大学 土建与水利学院,山东 济南 250061
  • 收稿日期:2013-10-10 出版日期:2015-02-11 发布日期:2018-06-13
  • 作者简介:刘健,男,1975年生,博士,副教授,主要从事岩土工程和结构工程等方面的教学与研究工作。
  • 基金资助:

    国家自然科学基金资助项目(No. 41172267);山东省自然科学基金资助项目(No. ZR2011EEM004)。

Backfilled grouting diffusion law and model of pressure on segments of shield tunnel considering viscosity variation of cement grout

LIU Jian, ZHANG Zai-song, HAN Ye, WU Xing   

  1. School of Civil Engineering, Shandong University, Jinan, Shandong 250061, China
  • Received:2013-10-10 Online:2015-02-11 Published:2018-06-13

摘要: 对水泥浆液黏度时变性进行了试验研究,证实了工程常用水灰比范围内水泥浆液服从宾汉姆流体特性;不同水灰比浆液黏度均随注浆时间增大而大幅度增加。根据试验结果,考虑注浆过程中水泥浆液黏度随时间的变化,对盾构壁后注浆水泥浆液的扩散规律及因注浆而造成的管片压力进行了推导及分析。计算表明:相同注浆时间条件下,水泥浆液扩散半径及注浆对管片产生的压力值均随注浆压力的增大而增大。考虑浆液黏度时变性后,扩散半径、注浆对管片压力值等均较不考虑浆液时变性时减小,且随注浆压力的增大,浆液黏度变化对管片压力值的影响更加明显。相同注浆压力条件下,浆液扩散半径及对管片产生的压力值均随注浆时间的增长而增加,但注浆前期增长速度较快,而后逐渐减缓。研究成果对于盾构壁后注浆工艺选择及参数设计具有较大的指导意义。

关键词: 盾构, 水泥浆液, 注浆, 黏度, 扩散规律, 管片压力

Abstract: Tests for time-dependent characteristics of cement grout are carried out, which find that cement grout of commonly used water-cement ratio conforms to Bingham fluid. Viscosities of grouts with different water-cement ratios increase greatly as grouting time increasing. According to the experimental results, considering the time-dependent characteristics of viscosity of cement grout, the diffusion law and model of pressure on segments of shield tunnel of backfilled cement grouting are found and derived respectively. A case is given. The results from theoretical calculation show that diffusion radius and pressure on the segments increase with the increase of grouting pressure when grouting time is constant on one hand. After considering viscosity variation of cement grout, diffusion radius and pressure on segment are smaller than the results obtained under fixed viscosity; and as the grouting pressure increases, the disturbance on pressure from viscosity of grout gets more obviously. On the other hand: when grouting pressure is constant, diffusion radius and pressure on the segments increase with the increase of grouting time. However, the values increase rapidly in the beginning and slow down later. The results can provide a guide to selecting appropriate techniques and parameters of cement grouting.

Key words: shield, cement grout, grouting, viscosity, diffusion law, segment pressure

中图分类号: 

  • TE 256
[1] 魏纲, 张鑫海, 林心蓓, 华鑫欣, . 基坑开挖引起的旁侧盾构隧道横向受力变化研究[J]. 岩土力学, 2020, 41(2): 635-644.
[2] 陈贺, 张玉芳, 张新民, 魏少伟, . 高压注浆钢花管微型桩抗滑特性 足尺模型试验研究[J]. 岩土力学, 2020, 41(2): 428-436.
[3] 杨振兴, 陈健, 孙振川, 游永锋, 周建军, 吕乾乾, . 泥水平衡盾构用海水泥浆的改性试验研究[J]. 岩土力学, 2020, 41(2): 501-508.
[4] 艾希, 冷伍明, 徐方, 张期树, 翟斌, . 新型预应力路基水平附加应力计算的图表法[J]. 岩土力学, 2020, 41(1): 253-266.
[5] 王忠凯, 徐光黎. 盾构掘进、离开施工阶段对地表变形的 影响范围及量化预测[J]. 岩土力学, 2020, 41(1): 285-294.
[6] 章定文, 刘志祥, 沈国根, 鄂俊宇, . 超大直径浅埋盾构隧道土压力实测分析 及其计算方法适用性评价[J]. 岩土力学, 2019, 40(S1): 91-98.
[7] 楼烨, 张广清. 压裂液黏度对循环水力压裂影响的试验研究[J]. 岩土力学, 2019, 40(S1): 109-118.
[8] 张治国, 李胜楠, 张成平, 王志伟, . 考虑地下水位升降影响的盾构施工诱发地层 变形和衬砌响应分析[J]. 岩土力学, 2019, 40(S1): 281-296.
[9] 黄大维, 周顺华, 冯青松, 罗锟, 雷晓燕, 许有俊, . 地表均布超载作用下盾构隧道上覆土层 竖向土压力转移分析[J]. 岩土力学, 2019, 40(6): 2213-2220.
[10] 莫振泽, 王梦恕, 李海波, 钱勇进, 罗跟东, 王辉, . 粉砂地层中浓泥土压盾构泥膜效应引起的 孔压变化规律试验研究[J]. 岩土力学, 2019, 40(6): 2257-2263.
[11] 徐辰宇, 白 冰, 刘明泽, . 注CO2条件下花岗岩破裂特征的试验研究[J]. 岩土力学, 2019, 40(4): 1474-1482.
[12] 张 聪, 梁经纬, 阳军生, 曹 磊, 谢亦朋, 张贵金, . 堤坝脉动注浆浆液扩散机制及应用研究[J]. 岩土力学, 2019, 40(4): 1507-1514.
[13] 魏久传, 韩承豪, 张伟杰, 谢 超, 张连震, 李孝朋, 张春瑞, 蒋记港, . 基于步进式算法的裂隙注浆扩散机制研究[J]. 岩土力学, 2019, 40(3): 913-925.
[14] 谢亦朋, 杨秀竹, 阳军生, 张聪, 戴勇, 梁雄, 龚方浩, . 松散堆积体隧道围岩变形破坏细观特征研究[J]. 岩土力学, 2019, 40(12): 4925-4934.
[15] 沙飞, 李术才, 林春金, 刘人太, 张庆松, 杨磊, 李召峰. 砂土介质注浆渗透扩散试验与加固机制研究[J]. 岩土力学, 2019, 40(11): 4259-4269.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 楚锡华,徐远杰. 基于形状改变比能对M-C准则与 D-P系列准则匹配关系的研究[J]. , 2009, 30(10): 2985 -2990 .
[2] 刘豆豆,陈卫忠,杨建平,谭贤君,周喜德. 脆性岩石卸围压强度特性试验研究[J]. , 2009, 30(9): 2588 -2594 .
[3] 王桂尧,李 斌,罗 军,付宏渊. 粉土基质吸力的新型量测装置与土-水特征研究[J]. , 2010, 31(11): 3678 -3682 .
[4] 王志萍,胡敏云,夏玲涛. 垃圾填土压缩特性的室内试验研究[J]. , 2009, 30(6): 1681 -1686 .
[5] 贾 强,应惠清,张 鑫. 锚杆静压桩技术在既有建筑物增设地下空间中的应用[J]. , 2009, 30(7): 2053 -2057 .
[6] 路军富,王明年,贾媛媛,喻 渝,谭忠盛. 高速铁路大断面黄土隧道二次衬砌施作时机研究[J]. , 2011, 32(3): 843 -848 .
[7] 王成华,安建国. 含扩径桩的群桩基础竖向承载性状数值分析[J]. , 2011, 32(S2): 580 -585 .
[8] 方 焘 ,刘新荣 ,耿大新 ,罗 照 ,纪孝团 ,郑明新 . 大直径变径桩竖向承载特性模型试验研究(I)[J]. , 2012, 33(10): 2947 -2952 .
[9] 胡万雨 ,陈向浩 ,林 江 ,况磊强 . 瀑布沟水电站砾石土心墙初次蓄水期原位钻孔渗流试验研究[J]. , 2013, 34(5): 1259 -1263 .
[10] 朱 星 ,许 强 ,汤明高 ,付小敏 ,周建斌 . 典型岩石破裂产生次声波试验研究[J]. , 2013, 34(5): 1306 -1312 .