›› 2015, Vol. 36 ›› Issue (10): 2773-2779.doi: 10.16285/j.rsm.2015.10.005

• 基础理论与实验研究 • 上一篇    下一篇

微生物沉积碳酸钙固化珊瑚砂的试验研究

方祥位1,申春妮2,楚 剑3,吴仕帆3,李依珊3   

  1. 1.后勤工程学院 土木工程系,重庆 401311;2.重庆科技学院 建筑工程学院,重庆 401331; 3.南洋理工大学 土木与环境工程学院,新加坡 639798
  • 收稿日期:2015-07-27 出版日期:2015-10-10 发布日期:2018-06-13
  • 作者简介:方祥位,男,1975 年生,博士,副教授,主要从事非饱和土与特殊土力学及岩土微生物技术研究。
  • 基金资助:
    国家自然科学基金资助(No.51479208,No. 11272354);总后勤部基建营房部资助项目(No. CY114C022)。

An experimental study of coral sand enhanced through microbially-induced precipitation of calcium carbonate

FANG Xiang-wei1, SHEN Chun-ni2, CHU Jian3, WU Shi-fan3, LI Yi-shan3   

  1. 1. Department of Civil Engineering, Logistical Engineering University, Chongqing 401311, China; 2. School of Civil Engineering and Architecture, Chongqing University of Science and Technology, Chongqing 401331, China; 3. School of Civil and Environmental Engineering, Nanyang Technological University, 639798, Singapore
  • Received:2015-07-27 Online:2015-10-10 Published:2018-06-13

摘要: 向珊瑚砂中注入巴斯德芽孢杆菌菌液、氯化钙和尿素的混合液,利用微生物沉积碳酸钙固化珊瑚砂;并对珊瑚砂固化体进行了渗透、强度及微观结构等试验。试验结果表明,巴斯德芽孢杆菌的活性随时间呈衰减趋势,但衰减速度缓慢,能较好地满足珊瑚砂固化的需要。随着菌液、氯化钙和尿素的混合液注入次数的增加,珊瑚砂柱渗透性逐步降低,最终渗透性降低了1~2个数量级。微生物固化后的珊瑚砂柱应力-应变曲线大致可分为3段,即应力随应变缓慢增加段、快速增加段以及突降段。试样发生压裂脆性破坏,无侧限抗压强度最高达到14 MPa左右。抗压强度随干密度增加而增大,随渗透性降低而增大。微生物固化后珊瑚砂颗粒被生成的碳酸钙完整的包裹,孔隙间极少见生成的碳酸钙,与普通硅砂微生物固化后的微观结构不同,较好地解释了渗透性降低不多的原因。

关键词: 珊瑚砂, 微生物, 碳酸钙, 固化, 微观结构

Abstract: By injecting Pasteur bacillus suspension and CaCl2-urea solution, the coral sand was solidified through the microbially-induced precipitation of calcium carbonate. Then a series of experiments including the permeability, strength and microstructure tests was conducted on the solidified soil. It is shown that the bacteria activity of Pasteur bacillus decreases slowly with time elapsing, which satisfies the requirement of the improving coral sand. Due to the bio-mediated improvement, the permeability of coral sand pillars decreases by 1 to 2 orders in magnitude. The stress-strain curve of improved coral sand pillars can be divided into 3 stages: stress increasing slowly with strain, stress increasing fast with strain and stress suddenly falling with strain. The unconfined compressive strength of specimen is up to 14 MPa before specimens being compressed into brittle failure. The compressive strength increases with the increase of dry density and the decrease of permeability. Unlike the silica sand improved by microbe, the coral sand improved by the current technology has a structure that the calcium carbonate precipitates wholly around coral sand particles. Hence the bonding between two particles by calcium carbonate is relatively weak, which properly explains the insignificant decrease of permeability.

Key words: coral sand, microbe, calcium carbonate, improvement, microstructure

中图分类号: 

  • TU 411
[1] 马维嘉, 陈国兴, 吴琪, . 复杂加载条件下珊瑚砂抗液化强度试验研究[J]. 岩土力学, 2020, 41(2): 535-542.
[2] 张善凯, 冷先伦, 盛谦, . 卢氏膨胀岩湿胀软化特性研究[J]. 岩土力学, 2020, 41(2): 561-570.
[3] 吴琪, 丁选明, 陈志雄, 陈育民, 彭宇, . 不同地震动强度下珊瑚礁砂地基中桩-土-结构 地震响应试验研究[J]. 岩土力学, 2020, 41(2): 571-580.
[4] 梁珂, 陈国兴, 刘抗, 王彦臻, . 饱和珊瑚砂最大动剪切模量的 循环加载衰退特性及预测模型[J]. 岩土力学, 2020, 41(2): 601-611.
[5] 梁珂, 何杨, 陈国兴, . 南沙珊瑚砂的动剪切模量和阻尼比特性试验研究[J]. 岩土力学, 2020, 41(1): 23-31.
[6] 李小刚, 朱长歧, 崔翔, 张珀瑜, 王睿, . 含碳酸盐混合砂的三轴剪切试验研究[J]. 岩土力学, 2020, 41(1): 123-131.
[7] 支永艳, 邓华锋, 肖瑶, 段玲玲, 蔡佳, 李建林. 微生物灌浆加固裂隙岩体的渗流特性分析[J]. 岩土力学, 2019, 40(S1): 237-244.
[8] 雷华阳, 胡垚, 雷尚华, 祁子洋, 许英刚, . 增压式真空预压加固吹填超软土微观结构特征分析[J]. 岩土力学, 2019, 40(S1): 32-40.
[9] 邓红卫, 罗益林, 邓畯仁, 伍礼杰, 张亚南, 彭述权. 微生物诱导碳酸盐沉积改善裂隙岩石防渗 性能和强度的试验研究[J]. 岩土力学, 2019, 40(9): 3542-3548.
[10] 韩钢, 周辉, 陈建林, 张传庆, 高阳, 宋桂红, 洪望兵, . 白鹤滩水电站层间错动带工程地质特性[J]. 岩土力学, 2019, 40(9): 3559-3568.
[11] 郑耀林, 章荣军, 郑俊杰, 董超强, 陆展, . 絮凝-固化联合处理超高含水率 吹填淤泥浆的试验研究[J]. 岩土力学, 2019, 40(8): 3107-3114.
[12] 沈泰宇, 汪时机, 薛乐, 李贤, 何丙辉, . 微生物沉积碳酸钙固化砂质黏性紫色土试验研究[J]. 岩土力学, 2019, 40(8): 3115-3124.
[13] 李 贤, 汪时机, 何丙辉, 沈泰宇, . 土体适用MICP技术的渗透特性条件研究[J]. 岩土力学, 2019, 40(8): 2956-2964.
[14] 王东星, 肖杰, 李丽华, 肖衡林, . 基于碳化-固化技术的武汉东湖淤泥 耐久性演变微观机制[J]. 岩土力学, 2019, 40(8): 3045-3053.
[15] 尹黎阳, 唐朝生, 谢约翰, 吕超, 蒋宁俊, 施斌, . 微生物矿化作用改善岩土材料性能的影响因素[J]. 岩土力学, 2019, 40(7): 2525-2546.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 黄建华,宋二祥. 大型锚碇基础围护工程冻结帷幕力学性态研究[J]. , 2009, 30(11): 3372 -3378 .
[2] 王观石,李长洪,陈保君,李世海. 应力波在非线性结构面介质中的传播规律[J]. , 2009, 30(12): 3747 -3752 .
[3] 王朝阳,许 强,倪万魁. 原状黄土CT试验中应力-应变关系的研究[J]. , 2010, 31(2): 387 -391 .
[4] 邓 琴,郭明伟,李春光,葛修润. 基于边界元法的边坡矢量和稳定分析[J]. , 2010, 31(6): 1971 -1976 .
[5] 万少石,年廷凯,蒋景彩,栾茂田. 边坡稳定强度折减有限元分析中的若干问题讨论[J]. , 2010, 31(7): 2283 -2288 .
[6] 闫 铁,李 玮,毕雪亮. 基于分形方法的多孔介质有效应力模型研究[J]. , 2010, 31(8): 2625 -2629 .
[7] 刘 嘉,王 栋. 正常固结黏土中平板锚基础的吸力和抗拉力[J]. , 2009, 30(3): 735 -740 .
[8] 赵尚毅,郑颖人,李安洪,邱文平,唐晓松,徐 俊. 多排埋入式抗滑桩在武隆县政府滑坡中的应用[J]. , 2009, 30(S1): 160 -164 .
[9] 刘振平,贺怀建,朱发华. 基于钻孔数据的三维可视化快速建模技术的研究[J]. , 2009, 30(S1): 260 -266 .
[10] 王国粹,杨 敏. 砂土中水平受荷桩非线性分析[J]. , 2011, 32(S2): 261 -267 .