岩土力学 ›› 2022, Vol. 43 ›› Issue (S1): 23-34.doi: 10.16285/j.rsm.2020.1418

• 基础理论与实验研究 • 上一篇    下一篇

盐穴储气库微渗层注浆封堵试验研究

刘元玺1, 2,李银平1, 2, 3,施锡林1, 2,赵凯1, 2   

  1. 1. 中国科学院武汉岩土力学研究所 岩土力学与工程国家重点试验室,湖北 武汉 430071;2. 中国科学院大学,北京 100049; 3. 中国科学院武汉岩土力学研究所 环境岩土工程湖北省重点实验室,湖北 武汉 430071
  • 收稿日期:2020-09-21 修回日期:2022-02-14 出版日期:2022-06-30 发布日期:2022-07-13
  • 通讯作者: 李银平,男,1969年生,博士,研究员,主要从事能源地下储备岩石力学与工程方面的研究工作。E-mail: ypli@whrsm.ac.cn E-mail:liuyuanxi_whrsm@163.com
  • 作者简介:刘元玺,男,1995年生,硕士研究生,主要从事盐穴地下储库密闭性方面的研究工作。
  • 基金资助:
    国家自然科学基金(No.51874273,No.51774266)

Experimental study on grouting method for plugging micro-permeable layer in salt cavern gas storage

LIU Yuan-xi1, 2, LI Yin-ping1, 2, 3, SHI Xi-lin1, 2, ZHAO Kai1, 2   

  1. 1. State Key Laboratory of Geomechanics and Geotechnical Engineering, Institute of Rock and Soil Mechanics, Chinese Academy of Sciences, Wuhan, Hubei 430071, China; 2. University of Chinese Academy of Sciences, Beijing 100049, China; 3. Hubei Key Laboratory of Geo-environmental Engineering, Institute of Rock and Soil Mechanics, Chinese Academy of Sciences, Wuhan, Hubei 430071, China
  • Received:2020-09-21 Revised:2022-02-14 Online:2022-06-30 Published:2022-07-13
  • Supported by:
    This work was supported by the National Natural Science Foundation of China(51874273, 51774266).

摘要: 我国盐穴地下储气库大多建造在具有不同渗透性的层状盐岩地层中,因此保证储库拥有良好的密闭性至关重要。针对盐穴井筒“裸眼段”意外跨越微渗地层而导致储气库密闭性失效的问题,自主研发了渗漏地层注浆封堵试验平台,并结合现场地质渗漏情况设计了注浆封堵可行性试验方案。在确定了兼具流动性和填充密实性的浆液配合比后,开展了超细水泥封堵岩芯的试验研究。结果表明,超细水泥可以有效填充岩芯孔隙并降低其渗透率,注浆后岩芯孔隙率和渗透率降幅分别达到近16%和95%。封堵试验数据显示浆液封堵范围与注浆时间呈幂函数关系,浆液流型满足幂律流,而非牛顿流。该研究成果可为盐穴储气库微渗地层注浆封堵提供必要的理论和试验依据,对类似密闭性失效井筒的二次利用具有重要意义。

关键词: 盐穴地下储气库, 微渗地层, 超细水泥, 注浆, 渗流运移

Abstract: The salt cavern underground gas storages in China are mostly built in layered salt rock strata with varying permeability. Ensuring good airtightness of the salt cavern gas storages is important. To solve the problem that the “open-hole section” of the wellbore accidentally traverses the micro-permeable layer and causes the airtightness failure of gas storage, a grouting test platform for plugging the micro-permeable layer was independently developed and a feasibility test of grouting plugging was designed based on the geological leakage situation on site. After determining the proportion of slurry with fluidity and filling compactness, an experimental study on plugging cores with ultra-fine cement was conducted. The test results show that the ultra-fine cement can effectively fill the pore and reduce the core permeability. The porosity and permeability of the cores are decreased by about 16% and 95% after the grouting tests. The plugging test data show that the plugging range is in the power function relationship with the grouting time, and the grout flow pattern satisfies the power law flow instead of the Newtonian flow. This study can provide theoretical and experimental basis for the grouting method to plug the micro-permeable layer in salt cavern gas storage, and it is critical for the secondary utilization of similar airtightness failure of the wellbore.

Key words: salt cavern underground gas storage, micro-permeable interlayer, ultra-fine cement, grouting, seepage migration

中图分类号: 

  • TE822
[1] 彭锐, 张升, 叶新宇, 雷宇, 李煜. 应用于压密注浆土钉的土工织物反滤性能试验研究[J]. 岩土力学, 2022, 43(S1): 339-347.
[2] 唐正, 王洪新, 孙德安, 张骁, . 大断面管幕法隧道群管顶进的地表位移规律研究[J]. 岩土力学, 2022, 43(7): 1933-1941.
[3] 路乔, 杨智超, 杨志全, 于荣霞, 朱颖彦, 杨溢, 张碧华, 王仁超, 方迎潮, 余东亮, 刘浩, 苏建坤, . 考虑扩散路径的宾汉姆流体渗透注浆机制[J]. 岩土力学, 2022, 43(2): 385-394.
[4] 崔溦, 王利新, 江志安, 王超, 王枭华, 张社荣, . 基于修正立方定律的岩体粗糙裂隙网络 注浆过程模拟研究[J]. 岩土力学, 2021, 42(8): 2250-2258.
[5] 周禹良, 侯公羽, 袁东锋, 李生生, 丁振宇, . 溶蚀孔隙型白云岩浆−水径向扩散模型及工程应用[J]. 岩土力学, 2021, 42(7): 1983-1994.
[6] 刘向阳, 程桦, 黎明镜, 王雪松, 张亮亮, 周瑞鹤, . 基于浆液流变性的深埋岩层纵向劈裂注浆理论研究[J]. 岩土力学, 2021, 42(5): 1373-1380.
[7] 窦金熙, 张贵金, 张熙, 范伟中, 宋伟, . 砂质土体脉动注浆浆−土耦合动力响应分析[J]. 岩土力学, 2021, 42(12): 3315-3327.
[8] 张浩, 施成华, 彭立敏, 雷明锋. 模袋袖阀管压密注浆的注浆压力理论计算方法研究[J]. 岩土力学, 2020, 41(4): 1313-1322.
[9] 陈贺, 张玉芳, 张新民, 魏少伟, . 高压注浆钢花管微型桩抗滑特性 足尺模型试验研究[J]. 岩土力学, 2020, 41(2): 428-436.
[10] 赵红芬, 周志鑫, . 利用铝−有机质絮状物降低渗透系数的试验研究[J]. 岩土力学, 2020, 41(12): 3947-3956.
[11] 杨庆光, 柳雄, 刘杰, 何杰, 梁凌川, 陈斌. 自由段先注浆对预应力锚索抗拔试验结果影响研究[J]. 岩土力学, 2020, 41(10): 3317-3325.
[12] 朱建民, 殷开成, 龚维明, 谢礼飞, . 中美欧自平衡静载试验标准若干问题探讨[J]. 岩土力学, 2020, 41(10): 3491-3499.
[13] 张 聪, 梁经纬, 阳军生, 曹 磊, 谢亦朋, 张贵金, . 堤坝脉动注浆浆液扩散机制及应用研究[J]. 岩土力学, 2019, 40(4): 1507-1514.
[14] 魏久传, 韩承豪, 张伟杰, 谢 超, 张连震, 李孝朋, 张春瑞, 蒋记港, . 基于步进式算法的裂隙注浆扩散机制研究[J]. 岩土力学, 2019, 40(3): 913-925.
[15] 谢亦朋, 杨秀竹, 阳军生, 张聪, 戴勇, 梁雄, 龚方浩, . 松散堆积体隧道围岩变形破坏细观特征研究[J]. 岩土力学, 2019, 40(12): 4925-4934.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 姚仰平,侯 伟. 土的基本力学特性及其弹塑性描述[J]. , 2009, 30(10): 2881 -2902 .
[2] 徐金明,羌培,张鹏飞. 粉质黏土图像的纹理特征分析[J]. , 2009, 30(10): 2903 -2907 .
[3] 向天兵,冯夏庭,陈炳瑞,江 权,张传庆. 三向应力状态下单结构面岩石试样破坏机制与真三轴试验研究[J]. , 2009, 30(10): 2908 -2916 .
[4] 石玉玲,门玉明,彭建兵,黄强兵,刘洪佳. 地裂缝对不同结构形式桥梁桥面的破坏试验研究[J]. , 2009, 30(10): 2917 -2922 .
[5] 夏栋舟,何益斌,刘建华. 土-结构动力相互作用体系阻尼及地震反应分析[J]. , 2009, 30(10): 2923 -2928 .
[6] 徐速超,冯夏庭,陈炳瑞. 矽卡岩单轴循环加卸载试验及声发射特性研究[J]. , 2009, 30(10): 2929 -2934 .
[7] 张力霆,齐清兰,魏静,霍倩,周国斌. 淤填黏土固结过程中孔隙比的变化规律[J]. , 2009, 30(10): 2935 -2939 .
[8] 张其一. 复合加载模式下地基失效机制研究[J]. , 2009, 30(10): 2940 -2944 .
[9] 易 俊,姜永东,鲜学福,罗 云,张 瑜. 声场促进煤层气渗流的应力-温度-渗流压力场的流固动态耦合模型[J]. , 2009, 30(10): 2945 -2949 .
[10] 陶干强,杨仕教,任凤玉. 崩落矿岩散粒体流动性能试验研究[J]. , 2009, 30(10): 2950 -2954 .