›› 2010, Vol. 31 ›› Issue (3): 986-992.

• 数值分析 • 上一篇    下一篇

洞室和围岩温度对泄洪洞衬砌混凝土温度和温度应力影响研究

陈 勤,段亚辉   

  1. 武汉大学 水资源与水电工程科学国家重点实验室,武汉 430072
  • 收稿日期:2008-10-06 出版日期:2010-03-10 发布日期:2010-03-31
  • 作者简介:陈勤,女,1984年生,硕士研究生,从事高坝与地下结构工程设计理论与混凝土温控防裂研究。

Influence of temperature in tunnel and surrounding rock on temperature and thermal stress of lining concrete of flood discharge tunnel

CHEN Qin,DUAN Ya-hui   

  1. State Key Laboratory of Water Resources and Hydropower Engineering Science, Wuhan University, Wuhan 430072, China
  • Received:2008-10-06 Online:2010-03-10 Published:2010-03-31

摘要:

以溪洛渡无压泄洪洞为研究对象,采用三维有限单元方法对不同洞室环境温度和围岩温度情况下的施工过程进行仿真模拟,通过比较底板、边墙和顶拱不同衬砌部位的最高温度、最大内表温差、最低温度、早期和冬季最大拉应力等,对洞室环境温度和围岩温度的变化对泄洪洞衬砌混凝土温度和温度应力,以及温度裂缝发生、发展与控制的影响进行分析。结果表明,洞室气温和围岩温度对衬砌混凝土的温度场和应力场均有明显的影响。在冬季施工衬砌混凝土更容易产生早期裂缝,夏季施工时既要防止早期裂缝,也要注意防止冬季裂缝。围岩温度低时,衬砌围岩侧混凝土拉应力明显增大,但对表面和中心的应力影响很小,因而对温度裂缝的发生影响很小。研究成果为隧洞工程衬砌混凝土的设计和施工提供有价值的参考。

关键词: 泄洪洞, 衬砌混凝土, 洞室气温, 围岩温度, 温度应力, 温度裂缝

Abstract:

Temperature in tunnel and temperature of surrounding rock which distribute in distinct regions and mountains are always different, and even have great differences sometimes. Accordingly, although under the same pouring materials and operating conditions, the temperature and the thermal stress of the lining concrete which will affect the occurrence and control of the temperature cracks to a great extent are also different. Taking Xiluodu free-flow tunnel as a research object, a 3-D finite element method is applied to simulate the construction process under conditions of different air temperatures in tunnel and temperature of surrounding rock. Through comparing the maximum temperature, maximum temperature difference between inner and surface, minimum temperature, maximum tensile stress in early period and winter, the effects of the change of temperature in tunnel and surrounding rock on the temperature and thermal stress of the lining concrete as well as occurrence, development and control of the temperature cracks are analyzed. The results show that both the temperature in tunnel and the temperature of surrounding rock have significant influences on the temperature field and stress field of the lining concrete. The lower the air temperature in tunnel is, the easier the early cracks will occur in winter; and it is necessary to prevent both early cracks in summer and winter cracks. The tensile stress of the lining concrete increases obviously when the temperature of the surrounding rock is low, however, the effect on the stress of the surface and inner is small; so the temperature of the surrounding rock has little effect on the temperature cracks. The research results provide valuable references for the design and construction of tunnel engineering.

Key words: flood discharge tunnel, lining concrete, temperature in tunnel, temperature of surrounding rock, thermal stress, temperature crack

中图分类号: 

  • TV 311
[1] 张 勇,项彦勇,. 饱和稀疏裂隙岩体三维水流-传热过程中位移和应力的一种半解析计算方法[J]. , 2016, 37(12): 3481-3490.
[2] 高俊义,项彦勇. 稀疏不规则裂隙岩体模型三维水流-传热对温度和应力影响的试验研究[J]. , 2016, 37(11): 3145-3155.
[3] 何朋立 ,王在泉,. 考虑温度效应的井壁竖向附加力反演分析[J]. , 2013, 34(12): 3425-3430.
[4] 刘 润 ,王秀妍 ,刘月辉 ,王武刚. 点支撑缺陷下海底埋管热屈曲分析[J]. , 2011, 32(S2): 64-69.
[5] 刘金龙 ,陈陆望 ,王吉利. 立井井壁温度应力特征分析[J]. , 2011, 32(8): 2386-2390.
[6] 刘杏红,周创兵,常晓林,周 伟. 大体积混凝土温度裂缝扩展过程模拟[J]. , 2010, 31(8): 2666-2670.
[7] 刘杏红,周创兵,常晓林,周 伟. 考虑非线性徐变的混凝土温度裂缝扩展过程模拟[J]. , 2010, 31(6): 1995-2000.
[8] 邓宗伟,冷伍明,李志勇,岳志平. 喷混凝土边坡温度场与应力场耦合的有限元时效分析[J]. , 2009, 30(4): 1153-1158.
[9] 刘杏红,周 伟,常晓林,周创兵. 改进的非线性徐变模型及其在混凝土坝施工期温度应力仿真分析中的应用[J]. , 2009, 30(2): 440-446.
[10] 陆培毅,韩丽君,于 勇. 基坑支护支撑温度应力的有限元分析[J]. , 2008, 29(5): 1290-1294.
[11] 苗 雨 ,万云冬 ,董玉凯,. 沥青路面反射裂纹温度应力的数值模拟[J]. , 2007, 28(S1): 343-347.
[12] 许四法 ,杨 杨 ,毛玉红,. HDPE土工膜温度应力的试验研究[J]. , 2006, 27(S2): 611-614.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 向天兵,冯夏庭,陈炳瑞,江 权,张传庆. 三向应力状态下单结构面岩石试样破坏机制与真三轴试验研究[J]. , 2009, 30(10): 2908 -2916 .
[2] 张宜虎,周火明,邬爱清. 结构面网络模拟结果后处理研究[J]. , 2009, 30(9): 2855 -2861 .
[3] 杨 光,孙 逊,于玉贞,张丙印. 不同应力路径下粗粒料力学特性试验研究[J]. , 2010, 31(4): 1118 -1122 .
[4] 闻世强,陈育民,丁选明,左威龙. 路堤下浆固碎石桩复合地基现场试验研究[J]. , 2010, 31(5): 1559 -1563 .
[5] 张常光,张庆贺,赵均海. 非饱和土抗剪强度及土压力统一解[J]. , 2010, 31(6): 1871 -1876 .
[6] 李卫超,熊巨华,杨 敏. 分层土中水泥土围护结构抗倾覆验算方法的改进[J]. , 2011, 32(8): 2435 -2440 .
[7] 张桂民 ,李银平 ,施锡林 ,杨春和 ,王李娟. 一种交互层状岩体模型材料制备方法及初步试验研究[J]. , 2011, 32(S2): 284 -289 .
[8] 王 伟 李小春 李 强 石 露 王 颖 白 冰. 小尺度原位瞬态压力脉冲渗透性测试系统及试验研究[J]. , 2011, 32(10): 3185 -3189 .
[9] 李术才 ,赵 岩 ,徐帮树 ,李利平 ,刘 钦 ,王育奎 . 海底隧道涌水量数值计算的渗透系数确定方法[J]. , 2012, 33(5): 1497 -1504 .
[10] 王洪新 ,孙玉永 . 考虑基坑开挖宽度的杆系有限元算法及试验研究[J]. , 2012, 33(9): 2781 -2787 .