超深孔一次成井微差爆破技术研究

›› 2012, Vol. 33 ›› Issue (6): 1742-1746.

超深孔一次成井微差爆破技术研究

李廷春，刘洪强，王超

山东省土木工程防灾减灾重点实验室山东科技大学山东青岛 266590

收稿日期:2012-01-12 出版日期:2012-06-11 发布日期:2012-06-14
作者简介:李廷春，男，1968年生，博士，副教授，硕士生导师，主要从事岩石工程爆破及裂隙岩体力学特性方面的研究工作。
基金资助:
中国煤炭工业协会计划项目(No. MTKJ2009-287)。

Study of millisecond blasting technology of shaft Excavation by one-step deep-hole blasting

LI Ting-chun，LIU Hong-qiang，WANG Chao

Shandong Provincial Key Laboratory of Civil Engineering Disaster Prevention and Mitigation, Shandong University of Science and Technology, Qingdao, Shandong 266590, China

Received:2012-01-12 Online:2012-06-11 Published:2012-06-14

摘要/Abstract

摘要： 起爆时差是超深孔一次成井爆破设计中的一个重要参数，合理设计起爆时差和起爆顺序，能够达到先起爆炮孔为后起爆炮孔创造良好自由面和补偿空间，实现筒状硐室分层、分段爆破的目的，并能降低围岩震动破坏。为合理选取起爆时差，基于超深孔微差爆破破岩机制，从理论上推导了一次成井预裂爆破延期时间，掏槽孔与相邻辅助孔、同分段辅助孔、相邻分段辅助孔的起爆时差等计算公式；同时提出了自下而上预裂爆破、先上下后中间光面爆破等6种一次成井起爆顺序。在华恒矿-650矸石仓，结合施工条件合理确定起爆时差等爆破参数，形成爆破设计方案。爆破过程中实现了分层、分段爆破，获得了良好的硐室成型，验证了形成的超深孔微差爆破技术是成功的，其结果对类似工程的实施具有一定的参考价值。

关键词: 一次成井, 微差爆破, 起爆时差, 起爆顺序

Abstract: The detonating delay time of millisecond blasting is an important parameter during shaft excavation by one-step deep-hole blasting. If detonating delay time and detonating sequences are reasonable, the millisecond blasting technology has many advantages. The foregoing blasting can create free face and compensating space for the following blasting to achieve the purpose of layered and segmented blasting. Also, the vibration damage of the surrounding rock can be reduced by decreasing detonated explosive charges in every turn. Based on deep-hole millisecond blasting theory, calculation methods of the detonating delay time of presplitting blasting, cut blasting, the same segmentation auxiliary holes blasting and the adjacent segmentation auxiliary holes blasting of shaft excavation by one-step deep-hole blasting are studied. In addition, six kinds of detonating sequences are put forward, such as bottom-up presplitting blasting, up and down before the middle smooth blasting, etc. The one-step deep-hole blasting technique is seen to meet the requirements in the Huaheng coal mine which proves that this research is applicable to other similar projects.

Key words: shaft excavation by one-step, millisecond blasting, detonating delay time, detonating sequences

中图分类号:

TD 265

李廷春，刘洪强，王超. 超深孔一次成井微差爆破技术研究[J]. , 2012, 33(6): 1742-1746.

LI Ting-chun，LIU Hong-qiang，WANG Chao. Study of millisecond blasting technology of shaft Excavation by one-step deep-hole blasting[J]. , 2012, 33(6): 1742-1746.

参考文献

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

本文评价

推荐阅读 10

[1]	赵延林，王卫军，曹平，王军，赵阳升. 不连续面在双重介质热-水-力三维耦合分析中的有限元数值实现[J]. , 2010, 31(2): 638 -644 .
[2]	孙德安，陈波. 重塑超固结上海软土力学特性及弹塑性模拟[J]. , 2010, 31(6): 1739 -1743 .
[3]	汪洋，唐雄俊，谭显坤，王元汉. 云岭隧道底鼓机理分析[J]. , 2010, 31(8): 2530 -2534 .
[4]	雷金波，陈从新. 基于双曲线模型的带帽刚性桩复合地基荷载传递机制研究[J]. , 2010, 31(11): 3385 -3391 .
[5]	王登科，刘建，尹光志，韦立德. 突出危险煤渗透性变化的影响因素探讨[J]. , 2010, 31(11): 3469 -3474 .
[6]	丁光亚，蔡袁强，徐长节. 饱和土中刚性排桩对平面SV波的隔离分析[J]. , 2009, 30(3): 849 -854 .
[7]	张成平，张顶立，骆建军，王梦恕，吴介普. 地铁车站下穿既有线隧道施工中的远程监测系统[J]. , 2009, 30(6): 1861 -1866 .
[8]	王军，曹平，李江腾，刘业科. 降雨入渗对流变介质隧道边坡稳定性的分析[J]. , 2009, 30(7): 2158 -2162 .
[9]	张渊，万志军，康建荣3，赵阳升. 温度、三轴应力条件下砂岩渗透率阶段特征分析[J]. , 2011, 32(3): 677 -683 .
[10]	唐世斌，唐春安，李连崇，张永彬. 湿度扩散诱发的隧洞时效变形数值模拟研究[J]. , 2011, 32(S1): 697 -0703 .