泥水盾构泥膜形成二维理论分析

›› 2013, Vol. 34 ›› Issue (6): 1593-1597.

泥水盾构泥膜形成二维理论分析

刘成¹，孙钧^{2, 3}，赵志峰¹，赵联桢¹

1.南京林业大学土木工程学院，南京 210037；2.同济大学岩土工程重点实验室，上海 200092；3.同济大学地下建筑与工程系，上海 200092

收稿日期:2012-03-30 出版日期:2013-06-10 发布日期:2013-06-14
作者简介:刘成，男，1982生，博士，讲师，主要从事地下渗流及动力分析方面的研究工作
基金资助:
国家自然科学基金资助项目（No. 51278251）；江苏高校优势学科建设工程资助项目；南京林业大学高学历人才基金项目（No. GXL201211）

Two-dimensional theoretical analysis of slurry membrane formation process in slurry shield

LIU Cheng¹, SUN Jun^{2, 3}, ZHAO Zhi-feng¹, ZHAO Lian-zhen¹

1. College of Civil Engineering, Nanjing Forestry University, Nanjing 210037, China; 2. Key Laboratory of Geotechnical and Underground Engineering of Ministry of Education, Tongji University, Shanghai 200092, China; 3. Department of Geotechnical Engineering, Tongji University, Shanghai 200092, China

Received:2012-03-30 Online:2013-06-10 Published:2013-06-14

摘要/Abstract

摘要： 在各种复杂环境下采用泥水盾构法修建隧道工程，需要解决在开挖面上如何及时形成安全有效的泥膜支护问题。采用修正的剑桥模型中正常固结黏土各向等压固结曲线规律，建立泥膜固含率与有效应力之间的关系，结合圆球形颗粒孔隙理想模型的渗透率以及泥膜固含率、渗透率和比阻三者之间的关系，确立新的泥膜形成本构关系模型。将泥膜形成一维模型拓展为二维模型，基于增量分析方法分析泥膜的增长规律，给出泥膜滤失量和厚度分别与位置、时间、重度比和盾构直径等因素的关系。结果表明，修正的剑桥模型能够较好地表征泥膜压缩固结特性；对于高压泥浆，泥浆重度对泥膜增长的影响较小，但对超大直径的盾构其影响不可忽略。

关键词: 泥水盾构, 泥膜形成, 泥浆悬浮液, 固含率

Abstract: To build the tunnel project by slurry shield method in a variety of complex environments needs to solve the problem that how to form safe and effective slurry membrane support timely on the excavation surface. The isotropic consolidation curves of the normal consolidation clay in the modified Cambridge model is used to establish the relationship between the membrane solid holdup and the effective stress of slurry membrane. Combining this with the permeability of ideal model of round sphere particle pore and the relationships among the membrane solid holdup, permeability and specific resistance of slurry membrane, a new constitutive model for the formation process of slurry membrane is established. The one-dimensional model is expanded to two-dimensional one, and the incremental analysis method of the formation process of slurry membrane is also given to study the increasing rules. Based on this, the relationship between slurry membrane filtration loss, and factors such as location, time, unit weight ratio and shield diameter are established. The results show that the modified Cambridge model could well characterize the compression consolidation properties of slurry membrane. Under high operating pressure, unit weight of slurry has little effect on membrane growth; but its influence cannot be ignored for super-large diameter shield.

Key words: slurry shield, slurry membrane formation, slurry suspension, solid holdup

中图分类号:

U 455.43

刘成，孙钧，赵志峰，赵联桢，. 泥水盾构泥膜形成二维理论分析[J]. , 2013, 34(6): 1593-1597.

LIU Cheng , SUN Jun , ZHAO Zhi-feng , ZHAO Lian-zhen,. Two-dimensional theoretical analysis of slurry membrane formation process in slurry shield[J]. , 2013, 34(6): 1593-1597.

参考文献

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

本文评价

推荐阅读 10

[1]	李鸿博，郭小红. 公路连拱隧道土压力荷载的计算方法研究[J]. , 2009, 30(11): 3429 -3434 .
[2]	瞿万波，刘新荣，傅晏，秦晓英. 洞桩法大断面群洞交叉隧道初衬数值模拟[J]. , 2009, 30(9): 2799 -2804 .
[3]	王川婴，胡培良，孙卫春. 基于钻孔摄像技术的岩体完整性评价方法[J]. , 2010, 31(4): 1326 -1330 .
[4]	李华明，蒋关鲁，刘先峰. CFG桩加固饱和粉土地基的动力特性试验研究[J]. , 2010, 31(5): 1550 -1554 .
[5]	谈云志，孔令伟，郭爱国，万智. 压实红黏土水分传输的毛细效应与数值模拟[J]. , 2010, 31(7): 2289 -2294 .
[6]	王生新，陆勇翔，尹亚雄，郭定一. 碎石土湿陷性试验研究[J]. , 2010, 31(8): 2373 -2377 .
[7]	王云岗，熊凯，凌道盛. 基于平动加转动运动场的边坡稳定上限分析[J]. , 2010, 31(8): 2619 -2624 .
[8]	龙照，赵明华，张恩祥，刘峻龙. 锚杆临界锚固长度简化计算方法[J]. , 2010, 31(9): 2991 -2994 .
[9]	徐志军，郑俊杰，张军，马强. 聚类分析和因子分析在黄土湿陷性评价中的应用[J]. , 2010, 31(S2): 407 -411 .
[10]	邓宗伟，冷伍明，李志勇，岳志平. 喷混凝土边坡温度场与应力场耦合的有限元时效分析[J]. , 2009, 30(4): 1153 -1158 .